Coordinates	40°37′29″N73°57′8″N
Name	Chevrolet Corvair
Manufacturer	Chevrolet Divisionof General Motors
Production	1959–1969
Model years	1960–1969
Class	Compact car
Engine	Flat-six
Layout	RR layout

The Chevrolet Corvair is a compact automobile produced by the Chevrolet division of General Motors for the 1960–1969 model years. It was the only American-made, mass-produced passenger car to feature a rear-mounted air-cooled engine.

The Corvair range included two-door coupe and convertible, four-door sedan, and four-door station wagon configurations, included the more powerful Monza model – and included passenger van, commercial van, and pickup derivatives. The range competed with imported cars such as the original Volkswagen Beetle, as well as the Ford Falcon and the Plymouth Valiant, new entries in a market segment that was established in the U.S. by the Nash and Rambler American.

The Corvair's legacy was affected by controversy surrounding its handling, its inclusion in Ralph Nader's book ''Unsafe at Any Speed'' and a subsequent National Highway Traffic Safety Administration (NHTSA) study saying the car's handling was as safe as that of its contemporaries.

History

Origin

The Corvair name originated for a 1954 Corvette fastback show car. The car's development was directed by Ed Cole, holding chief engineer and general manager positions at Chevrolet during the 1950s. It was General Motor's response to the growing popularity of small, lightweight imported cars such as the original Volkswagen Beetle, as well as to compete with domestic-built compact cars, the Rambler American and Studebaker Lark. The "compact" term was coined by George W. Romney as a euphemism for small cars with a wheelbase of or less. The Corvair's design began in 1956 with the first vehicles rolling off the assembly line in late 1959 for the 1960 model year. The car was introduced October 2, 1959 initially as a four-door sedan offered in two trim levels. Two Corvairs were tested at the Riverside International Raceway in California, for 24 hours. One car rolled over, but the other completed the drive consuming only one quart (0.95 L) of oil.

Overview

The Corvair's sales exceeded 200,000 for each of its first six model years. The rear engine design offered packaging and economy advantages, providing the car with a lower silhouette, flat passenger compartment floor, removing the need for power assists, and offering improvements in ride quality, traction, and braking balance. The different design also attracted customers from other makes, primarily imports. The Corvair stood out with engineering significantly different from other American offerings. It was part of GM's Y-body ("Z"-Body from 1965 on) line of cars, with design and engineering that advanced the rear-engine, rear-wheel drive layout pioneered by cars including the Tucker Torpedo, Porsche 356, Volkswagen Beetle, Renault Dauphine, and NSU Prinz—and employed by the concurrent and short-lived Hino Contessa.

engine]] The Corvair's powerplant is an aluminum air-cooled flat-six (Later enlarged, first to 145 and then to 164 cubic inches). The first Corvair engine produced . Power peaked with the 1965–66 turbocharged Corsa engine option. The first generation model's swing axle rear suspension, invented and patented by engineer Edmund Rumpler, offered a comfortable ride but raised safety concerns associated with the car's handling stability, and was replaced in 1965 with a fully independent rear suspension similar to the Corvette Sting Ray.

The Corvair represented several breakthroughs in design for mass-produced Detroit vehicles with 1,786,243 cars produced between 1960 and 1969.

Name	First generation
Production	1959–1964
Model years	1960–1964
Class	Compact car
Engine	Flat-6 Flat-6 (1961–63) (1964)
Transmission	3-speed manual4-speed manual2-speed Powerglide automatic
Body style	2-door convertible2-door coupe4-door sedan4-door station wagon6-door van8-door van2-door pickup truck
Platform	Y-body
Layout	RR layout
Related	Pontiac Tempest }}

First generation (1960–1964)

The 1960 Corvair 500 and 700 series four-door sedans were conceived as economy cars offering few amenities in order to keep the price competitive, with the 500 (base model) selling for under $2,000. Powered by an engine and three-speed manual or two-speed Powerglide automatic transmission, the Corvair was designed to have comparable acceleration to the six-cylinder full-size Chevrolet Biscayne. Introduced in January 1960, two-door models have a fold-down rear seat for added storage capacity, which was greatly needed as the spare tire was stowed in the forward trunk compartment.

The passenger compartment was heated by a gasoline heater mounted next to the spare tire in the luggage compartment. While it offered immediate hot air, customers complained of what they thought might be decreased gas mileage on cold days and through long winters. Chevrolet redesigned the heating system for the 1961 model year, yet left it up to customers to choose the gas heater until the end of the 1964 model year.

The line quickly grew from utilitarian bench seat sedans and coupes to the more plushly appointed bucket seat interiors of the new 900 series Monza. It hit showroom floors in the Spring 1960. Two available options on Monza were a more powerful engine, rated at thanks to a more radical camshaft paired with low-restriction exhaust, and the introduction of a fully-synchronized, four-speed transmission. Despite its late introduction, the Monza sold 12,000 units, making it one of the most popular Corvairs.

The Corvair was ''Motor Trend'' magazine's Car of the Year for 1960.

The 1961 Monza was heavily promoted and sometimes referred to as "the poor man's Porsche". The Monza series expanded with a four-door sedan body style in addition to the two-door coupe, and garnered about 144,000 sales.

A station wagon body-style, marketed as the Lakewood joined the lineup in 1961 with its engine located under the cargo floor and offering 68 ft³ (1.9 m³) of cargo room; 58 in the main passenger compartment, and another 10 in the front trunk. For 1961 an optional four-speed manual transmission was added. The Corvair engine received its first size increase to via a slight increase in bore size. The base engine was still rated at when paired with the manual transmissions and when mated to the optional automatic transmission in Monza models. The high-performance engine was rated at . To increase luggage capacity in the front trunk, the spare tire was relocated to the engine compartment (in cars not ordered with air-conditioning) and the gasoline heater was replaced by a system of ducts that redirected warmed air from the cylinder heads to the passenger compartment. The gasoline heater remained available as an option through 1964. Factory air conditioning was offered as a mid-1961 option introduction. The condenser lay flat atop the horizontal engine fan. A large, green-painted reverse rotation version of the standard GM Frigidaire air conditioning compressor was used, and an evaporator housing was added under the dash with integrated outlets surrounding the radio housing. Air conditioning was not available on wagons, Greenbrier/Corvair 95, or the turbocharged models introduced later due to space conflicts in those models. Chevrolet also introduced the Corvair 95 line of light-duty trucks, which used the Corvair driveline and are forward-control, with the driver sitting over the front wheels, as in the Volkswagen Type 2.

The Greenbrier Sportswagon used the same body as the "Corvan 95" panel van with the side windows option, but was marketed as a station wagon and was available with trim and paint options similar to the passenger cars. The "Corvan 95" model was also built in pickup versions; the Loadside was a fairly typical pickup of the era, except for the rear engine, forward controls, and a pit in the middle of the bed. The popular Rampside, which had a large fold-down ramp on the side of the pickup bed.

In 1962 Chevrolet introduced the turbocharged Monza Spyder option for Monza coupes and convertibles mid-year, making the Corvair the second production automobile to come with a turbocharger as a factory option, with the Oldsmobile F-85 Turbo Jetfire of the same year. The 500 station wagon was dropped in favor of the Monza wagon at introduction, however all station wagons were discontinued mid-year in favor the new Corvair Convertible and Chevy II (built at the same assembly plant). Self adjusting brakes were new for 1962. Metallic brake linings and a heavy duty suspension consisting of a front anti roll bar, rear axle limit straps, revised spring rates and recalibrated shock absorbers were introduced as optional equipment. The Monza Spyder featured a multi-gauge instrument cluster which included a tachometer, cylinder head temperature and intake manifold pressure gauges, Spyder fender script and Turbo logo deck emblems in addition to the high performance engine.

The Monza Coupe was the most popular model with 151,738 produced out of 292,531 total Corvair passenger car production for 1962.

The 1963 model year saw the availability of a long 3.08 gear for improved fuel economy, but the Corvair otherwise remained largely carryover with minor trim and engineering changes. The Loadside pickup was discontinued at the end of the model year.

For 1964 significant engineering and safety changes occurred, while the model lineup remained relatively unchanged. The engine displacement was increased from 145 to 164 cu in (2.3 to 2.7 L) due to an increase in stroke; the base engine power increased from 80 to 95 hp (60 to 70 kW), and the high performance engine increased from 95 to 110 hp (70 to 80 kW). The Spyder engine rating remained at 150 hp (112 kW) despite the displacement increase of the engine. 1964 saw an improvement in the car's swing axle rear suspension; a transverse leaf spring was added in an effort to diminish rear roll stiffness and foster more neutral handling attributes in addition to supporting a high proportion of the engine weight. Spring rates could now be softer at both ends of the car compared to previous models. The heavy duty suspension was no longer optional, although all models now had a front anti-roll bar as standard. Brakes were improved with finned rear drums. The remaining pickup, the Rampside, was discontinued at the end of the model year.

Name	Second generation
Production	1964–1969
Model years	1965–1969
Successor	Chevrolet Camaro
Class	Compact car
Engine	Flat-6
Transmission	3-speed manual4-speed manual2-speed Powerglide automatic
Body style	2-door convertible2-door hardtop4-door hardtop (1965–67)6-door van (1965)
Platform	Z-body
Layout	RR layout

Second generation (1965–1969)

A dramatic redesign of the Corvair came in 1965. The new body showed influence from the Corvette Stingray and the 1963 Buick Riviera. The mild coke bottle styling set the trend for GM cars for the next fifteen years, foreshadowing the 1967 Camaro. For the first time, none of the passenger cars had a "B" pillar, making all closed models true hardtops. The second generation's styling was rated timeless when new, and considered contemporary today in comparison to the first generation. A new fully independent suspension, similar in design to the Corvette, replaced the original swing axle rear suspension.

''Car and Driver'' magazine's David E. Davis Jr. showed enthusiasm for the 1965 Corvair in their October 1964 issue:

"And it is here too, that we have to go on record and say that the Corvair is — in our opinion — the most important new car of the entire crop of '65 models, and the most beautiful car to appear in this country since before World War II." "When the pictures of the '65 Corvair arrived in our offices, the man who opened the envelope actually let out a great shout of delight and amazement on first seeing the car, and in thirty seconds the whole staff was charging around, each wanting to be the first to show somebody else, each wanting the vicarious kick of hearing that characteristic war-whoop from the first-time viewer." "Our ardor had cooled a little by the time we got to drive the cars — then we went nuts all over again. The new rear suspension, the new softer spring rates in front, the bigger brakes, the addition of some more power, all these factors had us driving around like idiots — zooming around the handling loop dragging with each other, standing on the brakes — until we had to reluctantly turn the car over to some other impatient journalist ... The '65 Corvair is an outstanding car. It doesn't go fast enough, but we love it."

The base 95 hp (71 kW) and optional 110 hp (82 kW) engines were carried forward from 1964. The previous 150 hp (112 kW) Spyder engine was replaced by the normally aspirated 140 hp (104 kW) for the new Corsa. The engine was unusual in offering four single-throat carburetors, to which were added larger valves and a dual exhaust system; The 180 hp (134 kW) turbocharged engine was optional on the Corsa, which offered either standard three-speed or optional (US$92) four-speed manual transmissions. The 140 hp (104 kW) engine was optional on 500 and Monza models with manual or Powerglide transmissions.

Many new refinements appeared on the beautiful new 1965 redesign. The Corsa came standard with an instrument panel featuring a speedometer with resettable trip odometer, a 6,000 rpm tachometer, cylinder head temperature gauge, analog clock with a sweeping second hand, a manifold vacuum/pressure gauge and fuel gauge. A much better heater system, larger brakes borrowed from the Chevelle, a stronger differential ring gear, a Delcotron alternator (replacing the generator), and significant chassis refinements were made. AM/FM stereo radio, in-dash All Weather Air Conditioning, telescopically adjustable steering column, and a Special Purpose Chassis Equipment ("Z17") handling package, consisting of a special performance suspension and quick ratio steering box, were significant new options for 1965.

By this time, the station wagon, panel van, and pickup body styles had all been dropped and 1965 was the last year for the Greenbrier window van, which was retained mainly for fleet orders, with 1528 being built. In all, 235,528 Corvairs were built in 1965. Chevrolet replaced the Corvair-based vans with the Chevrolet Sportvan/GMC Handi-Van, which used a traditional front engine/rear drive axle borrowed from the Chevy II.

The 1966 lineup remained essentially unchanged from 1965. One change of note was a more robust 4-speed synchromesh transmission using the standard Saginaw gear set with 3.11:1 first gear ratio used by other GM 6-cylinder vehicles. A plastic air dam was installed below the front valence panel to conceal the front suspension and underbody, and lessen crosswind sensitivity. In front, The "lock door" emblem (covering the lockset for the trunk lock) was changed from red to blue and featured a shorter bar. The Corvair script nameplate was moved from atop the trunk lid to a position next to the driver's side headlight bezel. Sales began a decline as a result of Nader's book and the new Mustang that offered V8s up to compared to Corvair's top powertrain. and rumors of the upcoming "Panther'-the code name for the forthcoming Camaro, slated as a direct competitor for the Mustang. A decision was made to discontinue further development of the Corvair. Production for the model year was down to 103,743.

In 1967, the Corvair line was trimmed to the 500 and Monza Hardtop Coupes and Hardtop Sedans, and the Monza Convertible. This model year was the first with a collapsible steering column. A dual circuit master cylinder with warning light, nylon reinforced brake hoses, stronger steel (instead of aluminum) door hinges, "mushroomed" instrument panel knobs and a vinyl-edged day/night mirror were all made standard equipment. Chevrolet introduced a engine warranty on all Chevrolet models including the Corvair. Chevrolet was still actively marketing the Corvair in 1967, including color print ads and an "I Love My Corvair" bumper sticker campaign by dealers, but production and sales continued to fall off drastically. Only 27,253 copies were built.

In 1968, the four-door hardtop was discontinued, leaving three models—the 500 and Monza Hardtop Coupes and the Monza Convertible. All Weather air conditioning was dropped as an option, due to concerns about thermal loading added by the now-standard Air Injection Reactor ("smog pump") which probably hurt sales as factory air became more popular generally in automobiles. The GM multiplex stereo system was also discontinued when new units changed wiring adapters; the Corvair's 9-pin connector would no longer fit the new units. Additional safety features, including side marker lights, and shoulder belts for closed models, were fitted per the federal government's requirements. All advertising was virtually stopped and sales were down to 15,400.

The final model-year 1969 Corvairs were assembled with the Nova in Willow Run, Michigan, the same facility Corvairs had been built from the beginning. A total of 6,000 Corvairs were produced of which only 521 were Monza Convertibles. Demand for Novas was high and a decision was made in November 1968 to move Corvair assembly to a special off-line area in the plant, dubbed the "Corvair Room", making Corvairs produced between that time and May 14, 1969 essentially hand-built by a dedicated Corvair team. Assembled bodies arrived from Fisher Body and awaited assembly in the off-line area.

Stillborn third generation

Chevrolet had a proposed a third generation (1970-on) Corvair, essentially a re-skin of the 1965–69 model resembling the 1973 GM A Body intermediates, particularly the 1973 Pontiac Grand Am, retaining Corvair proportions. Having passed the point of full scale clay models, Chevrolet stopped developing the model in early 1968. Unlike the Turbo Hydramatic 400, the Turbo Hydramatic 350 transmission, introduced in the 1968 Camaro and later adopted by most Chevrolet models had been configured for use in the third generation Corvair.

End of production

According to noted GM historian Dave Newell, Chevrolet had planned on ending Corvair production after the 1966 model year. Development and engineering changes were halted in 1966 on the year-old, redesigned second-generation cars with mainly federally mandated emissions and safety changes made thereafter.

Ralph Nader, attorney and consumer advocate highlighted the Corvair's handling in his 1965 book ''Unsafe At Any Speed''. 1966 Corvair sales subsequently fell to half from the sales of 1965.

The Corvair faced competition from the Ford Mustang, Chevy's own Camaro, and other pony cars. The car had been costly to produce, yet was not offered at a premium price; not a high profit earner for Chevrolet as was the Corvette for example. An increasing lack of interest from the company, especially from Chevrolet's General Manager John DeLorean, and a complete absence of Corvair advertising after 1967 reflected the company's priorities, including promotion of three redesigned models for 1968—the Corvette, Chevelle and Chevy II Nova.

The Corvair was referred to as "the phantom" by ''Car Life'' magazine in their 1968 Monza road test, and by 1969 Chevrolet's Corvair four-page brochure was "by request only". During its final year of production, 6000 cars were produced.

Handling controversy

First Generation (1960–1963) Corvair handling characteristics became the subject of controversy when Ralph Nader addressed them in his 1965 book, ''Unsafe at Any Speed''. GM had over 100 lawsuits pending in connection with accidents involving the Corvair, which subsequently became the initial material for Nader's investigations. The book highlighted accidents related to the Corvair's suspension and identified the Chevrolet suspension mechanic who had fought management for removing (for cost reasons) the front anti-sway bar installed on later models. Nader's book cited a promotional film created by Ford Motor Company, in which a Ford test driver purposely turned the Corvair in a way to make it appear unstable, as evidence against the Corvair. Nader said during subsequent Congressional hearings, the Corvair is "the leading candidate for the un-safest-car title." Subsequently, Corvair sales fell from 220,000 in 1965 to 109,880 in 1966. By 1968 production fell to 14,800. Public response to the book played a role in the National Traffic and Motor Vehicle Safety Act in 1966.

A 1972 safety commission report conducted by Texas A&M; University concluded that the 1960–1963 Corvair possessed no greater potential for loss of control than its contemporaries in extreme situations. The U.S. Department of Transportation (DOT) issued a press release dated August 12, 1972, setting out the findings of NHTSA testing from the previous year — after the Corvair had been out of production for more than three years. NHTSA had conducted a series of comparative tests in 1971 studying the handling of the 1963 Corvair and four contemporary cars, a Ford Falcon, Plymouth Valiant, Volkswagen Beetle, Renault Dauphine—along with a second generation Corvair (with its completely redesigned, independent rear suspension). The subsequent 143-page report (PB 211-015, available from NTIS) reviewed NHTSA's extreme-condition handling tests, national accident data for the cars in the test as well as General Motors/Chevrolet internal documentation regarding the Corvair's handling. NHTSA went on to contract an independent advisory panel of engineers to review the tests. This review panel issued their own 24 page report (PB 211-014, available from NTIS)—which concluded that "the 1960–63 Corvair compares favorably with contemporary vehicles used in the tests...the handling and stability performance of the 1960–63 Corvair does not result in an abnormal potential for loss of control or rollover, and it is at least as good as the performance of some contemporary vehicles both foreign and domestic." Former GM executive John DeLorean asserted in ''On a Clear Day You Can See General Motors'' (1979) that Nader's criticisms were valid.

''Car and Driver'' magazine criticized Nader for ignoring the need of drivers to cope with changes in driving style when operating the Corvair, not least keeping the rear tires properly inflated. None of the issues Nader raised were problems among owners of the Porsche 911, which had the same layout and similar suspension, nor with the less powerful Volkswagen Type 1 Beetle.

Journalist David E. Davis, in a 2009 article in ''Automobile Magazine'', noted that despite Nader's claim that swing-axle rear suspension were dangerous, Porsche, Mercedes-Benz and Volkswagen all used similar swing-axle concepts during that era.

Handling characteristics

[[File:Swing Axle Diagram.svg|thumb|250px|left|Swing axle suspension characteristics: : camber change on bumps, jacking on rebound]]

The first generation Corvair featured a rear swing axle design similar to that of the Renault Dauphine and Volkswagen Beetle – a design which eliminates universal joints at the wheels and where the rear wheels are always perpendicular to the driveshafts. The design can allow rear tires to undergo large camber angle changes during fast cornering, leading to oversteer—a dynamically unstable condition where a vehicle can lose control and spin — and in extreme cases produce lift-off oversteer.

Design options to ameliorate Swing-Axle handling:

Anti-roll bar: As a design option, engineers had advocated but management rejected the inclusion of a front anti-roll bar on the original 1960 Corvair, which would have ameliorated the car's handling – shifting weight transfer to the front outboard tire, considerably reducing rear slip angles—thereby avoiding potential oversteer.

Tire pressure differential: As with the Renault Dauphine and pre-1968 Volkswagen Beetle, Corvair engineers relied on a cost-free ''tire pressure differential'' to eliminate oversteer characteristics – low front and high rear tire pressure – a strategy which induced understeer (increasing front slip angles faster than the rear). Nonetheless, the strategy offered a significant disadvantage: owners and mechanics could inadvertently but easily re-introduce oversteer characteristics by over-inflating the front tires (e.g., to typical pressures for other cars with other, more prevalent suspension systems).

While the Corvair offered competent handling, "the average buyer more accustomed to front-engined cars, did not take [into] account the car's different handling characteristics." Chevrolet made a succession of improvements to the first generation Corvair suspension. For the 1962 model year, the front anti–roll bar became available as an option. For the 1964 model year, the front anti-roll bar became standard equipment and the rear suspension was modified to include a camber compensating, transverse-mounted leaf spring extending between the rear wheels to limit rear wheel camber change, and carrying much of the rear weight combined with softer coil springs.

For the 1965 model year, the Corvair received a fully independent rear suspension closely resembling that of the contemporary Corvette. The redesigned suspension reduced the rear roll center to half its previous height, using fully articulated half-axles that offered constant camber on the rear tires in all driving situations.

Reception

''Time (magazine)'' featured Ed Cole and the 1960 Corvair on its cover for the Corvair introduction in 1959 and said: "its fresh engineering is hailed as the forerunner of a new age of innovation in Detroit." ''Time'' reported in 1960: Chevrolet sold 26,000 Corvairs its first two days on the market, taking over 35% of Chevy's two-day total of 75,000. Chevrolet had intended to sell one Corvair for every five Chevrolets. By March 1960, the Corvair comprised 13% of Chevrolet's sales. Shortly after its introduction, the Corvair faced competition from the Ford Falcon and Mercury Comet and was plagued by problems—though according to a 1960 ''Time'' report, "many were the minor bugs that often afflict a completely new car." Problems included a slipping fan belt, carburetor icing and poor fuel mileage "which sometimes runs well under 20 m.p.g." The 1960 model gasoline heater was cited as a problem, which itself could consume up to a quart of gas an hour—with Chevrolet engineers quickly modifying the Corvair's carburetors to improve economy.

''Motor Trend'' awarded the Corvair its "Car of the Year" award for 1960.

''Car and Driver'' reported upon introduction of Corvair's revised second generation – Editor David E. Davis said: "We have to go on record and say that the Corvair is – in our opinion – the most important new car of the entire crop of '65 models, and the most beautiful car to appear in this country since before World War II."

In 2007 ''Time (magazine)'' named the Corvair one of the ''50 Worst Cars of All Time'', citing the controversy surrounding its rear-suspension and saying it "It leaked oil like a derelict tanker. Its heating system tended to pump noxious fumes into the cabin. It was offered for a while with a gasoline-burner heater located in the front "trunk", a common but dangerously dumb accessory at the time."

Production notes

{|class=wikitable |- !Year!!Production!!Base Price!!Notes |- align=center | 1960 ||253,268||||align=left|500 and 700 4-door sedan are only models available at introduction; 500 and 700 Club Coupe become available January 1960, Monza Club Coupe introduced spring 1960 with "Super Turbo Air" high performance engine option, and 4-speed transmission, gas heater optional, spare tire mounted in luggage compartment, central automatic choke. Sales impeded by U.S. Steel strike shortly after introduction, causing a shortage of new 1960 models. Monza is the first Chevrolet model with 'narrow' stripe whitewall tire. |- align=center | 1961 || 337,371 || ||align=left|Lakewood station wagon, Greenbrier, Corvan, and Loadside and Rampside pickups added; 145 in³ engine and optional three-speed manual; spare tire now rear-mounted on models not equipped with mid 1961 All Weather Air Conditioning option. Manual choke. First full year of Monza production demonstrates its sales success, pushes Ford to develop Falcon Sprint and eventually Mustang to exploit the small sporty car market uncovered by Corvair Monza. |- align=center | 1962 || 336,005 || ||align=left|Monza Convertible and Turbocharged Monza Spyder added mid-1962, heavy duty suspension optional with front anti roll bar, rear axle limit straps, positraction differential, new Monza full wheel covers, Kelsey Hayes knock off wire wheels added to options, Monza wagon becomes available, 500 wagon dropped- wagons lose 'Lakewood' designation. Station wagons discontinued mid-1962 to provide capacity for other Corvair and Chevy II models. |- align=center | 1963 || 288,419 || ||align=left|Self adjusting brakes and small engine improvements (belt guides, improved oil cooler), new Monza rocker moldings, Loadside pickup discontinued. |- align=center | 1964 || 214,483 || ||align=left|Larger 164 CID engine, improved rear suspension with added transverse leaf spring and revised coil springs, front stabilizer bar added as standard, finned rear brake drums, new optional full wheel covers-std. for Monza with specific centers, new Monza chrome rocker and wheel opening moldings, last year for Rampside pickup. |- align=center | 1965 || 247,092 || ||align=left|Major redesign of the Corvair- all new Fisher Z body, hardtop styling for all models, 700 series discontinued, Corsa series replaces Monza Spyder series; Greenbrier discontinued mid-year after 1528 built; revised front and redesigned fully independent rear suspension, improved heater and air conditioning systems, numerous small engine and chassis refinements. Mid year introduction of Z17 'steering and suspension" option includes special springs with rates increased approximately 25%, special shock absorbers, a 16:1 steering box and special steering arms. New options include engine, telescopic steering column, AM/FM, FM stereo, heavy duty oil bath air cleaner precleaner system with engine shrouding for dust control. Front Chevy emblem painted red. |- align=center | 1966 || 109,880 || ||align=left|Improved 3 and 4-speed synchromesh manual transmissions; last year of Corsa model, Last year of Canadian production at Oshawa. Late 1965 modification to steering shaft adds a U-joint and floor reinforcement to reduce risks of column intrusion in collisions. Tire size upgraded to 7.00–13 from 6.50–13, with narrower whitewall. New "spoke" style wheel covers for all models with specific model centers. Front Chevy emblem now blue (remaining this color until the end of production). New optional equipment includes headrests, shoulder harnesses, 4-speaker Delco FM Stereo Multiplex, power rear antenna, 'Mag Style' (N96) wheelcovers. |- align=center | 1967 || 27,253 || ||align=left|Last year for the four-door hardtop sedan, GM Energy Absorbing steering column, dual circuit brake system, stronger door hinges introduced. New safety three-spoke steering wheel standard. Four-way hazard flashers, lane-change turn signal control, additional padding on instrument panel cover, safety control knobs introduced. engine is only optional engine at introduction; eventually becomes available as Central Office Production Order in limited production as COPO 9551"B". New "safety" Powerglide shift knob, shoulder belt mount points added. New style standard hub caps for 500. Chrome ring inside taillight lenses widened. New options included Speed Warning, Delco Stereo Tape system. New thin-shell "Astro-bucket" front seats with new vinyl pattern standard on Monzas. |- align=center | 1968 || 15,399 ||||align=left|Air Injection Reactor standard in all markets, engine reintroduced as a regular production option, optional All Weather Air Conditioning discontinued, multiplex stereo option discontinued; fuel vapour return line and Ignition Key Warning buzzer new standard features. Front shoulder harnesses become standard after Jan 1, 1968, rear shoulder harnesses are optional all models. Side marker lights (clear in front with amber bulbs, red in rear) added to fenders on all models. New padding around central section of dash; thicker padding on top of dash, steering wheel spokes on Monzas now brushed aluminum (instead of chrome). |- align=center | 1969 || 6,000 ||||align=left|Last year—production through May 1969; 521 Monza Convertibles of 6000 Corvairs produced; minor changes; improved clutch cable design on manual transmission cars, wider bucket seats with new head restraints, wider interior mirror, refined front brake hose design, Front side markers now feature amber lenses and clear bulbs (opposite from '68). engine, F41 'special purpose suspension', N44 'quick ratio steering box' Positraction and telescopic steering column remain available. Interior window handles featured clear-colored knobs. Deluxe steering wheel option discontinued. New style ignition, door and trunk keys introduced. The last few months of production cars were hand-built on a special off-line area of the Willow Run plant. |- !Total!!1,835,170!!!! |} Corvair Production (Model years)

All locations are cars only, except as noted

Willow Run 1960-69 Kansas City 1960-61 Oakland, CA 1960-63 Van Nuys, CA 1963, 1965 & 1966 St Louis, MO 1961-65 (FCs) Flint, MI 1961-64 (FCs) Oshawa, Ontario 1960-66 Mexico City 1961-63 (CKD) Caracas, Venezuela 1960-62 (CKD) Bienne, Switzerland 1960-67 (CKD) Antwerp, Belgium 1960-67 (CKD) Copenhagen, Denmark 1960-61 Port Elizabeth, South Africa 1960-62 (All 1960 CKD models)

Note that WR, KC, Oakland, & VN were Chevrolet assembly plants with adjacent Fisher Body plants. St Louis & Flint were Chevrolet truck plants, although Chevy had full-size car plants in both cities and in St Louis the plants were adjacent.

Oshawa was operated solely by GM of Canada Ltd.

The CKD plants were operated by GM Overseas Operations (GMOO).

Concept cars

The Corvair spawned a number of innovative concept vehicles including the Corvair SS, Monza GT, Monza SS, Astro I, and even two Carrozzeria Pininfarina "Corvair Speciale" show cars and the Testudo, designed by Carrozeria Bertone.

The Chevrolet Corvair Monza GT coupe toured together with the Monza SS (Spyder) in early 1963, making a further public appearance at the New York Auto Show. Although both cars were based on the Corvair drive train, each represented a futuristic development of the adaptable Corvair design. In the SS convertible, the engine (with a four-carburetor setup) was left in its stock location behind the transaxle, allowing a shorter () wheelbase. Although the SS came very close to production, both cars remained concepts only. The Monza GT is housed at the GM's Heritage Center in Detroit.

A 1966 concept vehicle, the Electrovair II, was a 1966 Monza modified with a 532 volt 115-horsepower electric motor replacing the gasoline engine — following a 1964 version known as Electrovair I. With the 1966 model, silver-zinc batteries were used and placed in the trunk and engine compartment, and the body was slightly modified to accept the conversion. The car was handicapped by the high cost of the batteries ($160,000), a limited driving range (40–80 miles), and short battery life.

Racing and modified Corvairs

Yenko Stinger

Don Yenko, who had been racing Corvettes, could not compete successfully against the Carroll Shelby Mustangs after they arrived on the scene; he therefore decided to race modified Corvairs, beginning with the 1966 model. As the stock Corvair did not fit into any of the SCCA categories, Yenko had to modify four-carburetor Corsas into "sports cars" by removing the back seat; in the process he introduced various performance improvements. As the SCCA required 100 cars to be manufactured to homologate the model for production racing, Yenko completed 100 Stingers in one month in 1965. Although all were white, as the SCCA required for American cars at the time, there was a great deal of variety between individual cars; some had exterior modifications including fiberglass engine covers with spoilers, some did not; some received engine upgrades developing 160, 190, 220, or 240 hp (119, 142, 164, or 179 kW). All were equipped by the Chevrolet factory with heavy duty suspension, four speed transmission, quicker steering ratio, positraction differentials (50 with 3.89 gears, and 50 with 3.55 when Chevrolet dropped the 3.89) and dual brake master cylinders (the first application of this by Chevrolet, to become stock equipment the next year).

The Stingers competed in Class D Production, which was dominated by the Triumph TR4, which was very quick in racing trim; however in its first race in January 1966, the Stinger was able to come in second by only one second. By the end of the 1966 season, Jerry Thompson had won the Central Division Championship and placed fifth in the 1966 Nationals, Dick Thompson, a highly successful Corvette race driver, had won the Northeast Division Championship, and Jim Spencer had won the Central Division Championship, with Dino Milani taking second place. The next year, however, Chevrolet dropped the Corsa line, and the Monza line was not initially available stock with the four carburetor engine; the engine was eventually offered as a special performance option, however, along with the 3.89 differential. The Monza instrumentation did not have a tachometer or head temperature gauges, which had to be separately installed. The SCCA, on the other hand, had relaxed its ruling regarding color, and the cars were available in red or blue. It is believed that only fourteen 1967 Stingers were built, but Dana Chevrolet, who distributed Stingers on the U.S. West Coast, ordered an additional three similar cars to be built to Stinger specifications, but with the AIR injection system to meet California emissions laws, with Yenko's permission. A total of 185 Stingers are believed to have been built, the last being YS-9700 built for Goodyear Tire and Rubber Company as a tire test vehicle in 1969–1970. Comedian, television star, and car enthusiast Tim Allen owned and raced Yenko Stinger #YS-043 until he sold it around June, 2009.

Fitch Sprint

Longtime roadracer John Fitch was particularly interested in the Corvair as the basis for a spirited road and track oriented car, due to its handling. The basic Sprint received only minor modifications to the engine, bringing it to 155 hp (116 kW), but upgrades to the shock absorbers and springs, adjustments to the wheel alignment, quicker steering ratio, alloy wheels, metallic brake linings, the obligatory wood-rimmed steering wheel (leather available for an additional $9.95) and other such minor alterations made it extremely competitive with European sports cars costing much more. Body options such as spoilers were available, but the most visually remarkable option was the "Ventop", a fiberglass overlay for the C-pillars and rear of the roof that gave the car a "flying buttress" profile.

Fitch went on to design and build a prototype of the Fitch Phoenix, a Corvair-based two-seat sports car, superficially resembling a smaller version of the Mako Shark based Corvette. With a total weight of 1,950 pounds (885 kg), even with a steel body, and with the Corvair engine modified with Weber carburetors to deliver 175 hp (130 kW), the car delivered spirited performance for $8,760. Unfortunately, the Traffic Safety Act of 1966 placed restrictions on the ability to produce automobiles on a small scale; this was followed by Chevrolet's decision to terminate production of the Corvair, which confirmed the end of Fitch's plan. He still retains the prototype however, and occasionally exhibits it at car shows. The car may be glimpsed briefly in the documentary film ''Gullwing at Twilight: The Bonneville Ride of John Fitch''.

Custom, dune buggies and aircraft

Corvair flat-six engines were a popular alternative to Volkswagen engines in dune buggy applications, and off-road racing. Some Corvair engines have also been used to power light aircraft. Customizer Gene Winfield created the ''Reactor''' aluminum car, using a turbocharged Corvair engine to drive the front wheels, with other drivetrain components, including the chassis, from a Citroën DS. This vehicle appeared in numerous television programs in the 1960's, including Star Trek

Photo gallery

See also

Chevrolet Corvair engine

Chevrolet Corvair Powerglide

Yenko Chevrolet

''Unsafe at Any Speed''

References

Bibliography

Cheetham, Craig. ''The World's Worst Cars: From Pioneering Failures to Multimillion Dollar Disasters''. New York: Barnes & Noble, 2005. ISBN 0-7607-6743-2.

Shattuck, Dennis, ed. ''Corvair – A complete Guide'' (A Car Life Special Edition). Chicago: Bond Publishing Company, 1963.

External links

Filmstrip Advertisement for the Corvair from the Prelinger Archives at archive.org

Corvair Corvair Category:Rear wheel drive vehicles Category:Rear-engined vehicles Category:Compact cars Category:Pickup trucks Category:Sedans Category:Vehicles with boxer engines Category:1960s automobiles Category:Motor vehicles manufactured in the United States

de:Chevrolet Corvair es:Chevrolet Corvair fr:Chevrolet Corvair lt:Chevrolet Corvair ja:シボレー・コルヴェア pl:Chevrolet Corvair pt:Chevrolet Corvair ru:Chevrolet Corvair fi:Chevrolet Corvair sv:Chevrolet Corvair tr:Chevrolet Corvair

Coordinates	40°37′29″N73°57′8″N
name	Jimmy Dean
background	solo_singer
birth name	Jimmy Ray Dean
born	August 10, 1928Plainview, Texas, United States
died	June 13, 2010Varina, Virginia, United States
instrument	Vocals, guitar
genre	Country
occupation	Singer, actor, businessman
years active	1953–2010
label	Columbia RecordsRCA Records
associated acts	Roy Clark, Patsy Cline, Charlie Rich
website	Dean's Website }}

Jimmy Ray Dean (August 10, 1928 – June 13, 2010) was an American country music singer, television host, actor and businessman. Although he may be best known today as the creator of the Jimmy Dean sausage brand, he became a national television personality starting in 1957, rising to fame for his 1961 country crossover hit "Big Bad John". His acting career included a supporting role as Willard Whyte in the 1971 James Bond movie, ''Diamonds Are Forever''. He lived near Richmond, Virginia and was nominated for the Country Music Hall of Fame in 2010, although he was formally inducted posthumously.

Biography

Early life

Dean was born in Plainview, Texas, in 1928, the son of George Otto Dean and his second wife Ruth (née Taylor) Dean. He attributed his interest in music to the Seth Ward Baptist Church. He dropped out of high school and became a professional entertainer after a stint in the U.S. Air Force in the late 1940s.

Entertainment career

Dean had his first hit, "Bummin' Around", in 1953 on the 4 Star label, but had no other hits for the rest of the decade. He signed with Columbia Records in 1957.

In 1954, Dean hosted the popular Washington D.C. radio program ''Town and Country Time'' on WARL-AM, and with his Texas Wildcats became popular in the Mid-Atlantic region. Patsy Cline and Roy Clark got their starts on the show. Although Cline and Dean became good friends; Clark, Dean's lead guitarist, was eventually fired by the singer for what was explained as his chronic tardiness. Dean replaced Clark with Billy Grammer. In 1955, ''Town and Country Time'' moved to WMAL-TV on weekday afternoons. Dean and the Texas Wildcats also appeared during 1957 on ''Town and Country Jamboree'' on WMAL-TV on Saturdays from 10:30 p.m.–1:30 a.m. ET, which was also carried by TV stations in Maryland and Virginia on a regional network.

Also during 1957, Dean hosted ''Country Style'' on WTOP-TV on weekday mornings. CBS picked up the show nationally from Washington for eight months in 1957 under the name, ''The Morning Show''. Then from September 14, 1958–June 1959, CBS carried ''The Jimmy Dean Show'' on weekday and Saturday afternoons.

Dean became best known for his 1961 recitation song about a heroic miner, "Big Bad John". Recorded in Nashville, the record went to number one on the ''Billboard'' pop chart and inspired many imitations and parodies. It sold over one million copies, and was awarded a gold disc. The track peaked at No. 2 in the UK Singles Chart. The song won Dean the 1962 Grammy Award for Best Country & Western Recording. He had several more Top 40 songs including a Top 10 in 1962 with "PT-109", a song in honor of John F. Kennedy's bravery in World War II.

In the early 1960s, he hosted the ''Tonight Show'' on occasion and one night introduced Roy Clark, with whom he had remained friendly. In the mid-60s, Dean helped bring country music into the mainstream with his 1963–66 ABC-TV variety series, ''The Jimmy Dean Show''. It presented country music entertainers including Roger Miller, George Jones, Charlie Rich, Buck Owens and some, like Joe Maphis, who seldom received network exposure. The program also featured comedy and a variety of popular music artists, and Dean's sketches with one of Jim Henson's Muppets, Rowlf the Dog.

Dean appeared on several TV talk shows and game shows in the 1960s and performed on variety programs including ''The Ed Sullivan Show'', ''The Pat Boone Chevy Showroom'', and ''The Hollywood Palace''.

Dean turned to acting after his TV show ended in 1966. His best-known role was as reclusive Las Vegas billionaire Willard Whyte in the 1971 James Bond movie, ''Diamonds Are Forever''. He also appeared in fourteen episodes of ''Daniel Boone'' (1967–70) in three different roles (one episode as "Delo Jones", two as "Jeremiah" and eleven as "Josh Clements") and as Charlie Rowlands in two ''Fantasy Island'' episodes (1981–82), as well as on other TV shows including a semi-regular role as Charlie Bullets on ''J.J. Starbuck'' starring Dale Robertson (1987–88).

Dean's singing career remained strong into the mid-1960s; in 1965, he achieved a second number one country hit with the ballad "The First Thing Ev'ry Morning (And the Last Thing Ev'ry Night)", and he had a Top 40 hit that year with "Harvest Of Sunshine". In 1966, Dean signed with RCA Records and immediately had a Top 10 hit with "Stand Beside Me". His other major hits during this time included "Sweet Misery" (1967) and "A Thing Called Love" (1968). He continued charting into the early 1970s with his major hits including a duet with Dottie West, "Slowly" (1971); and a solo hit with "The One You Say Good Morning To" (1972).

In 1976, Dean achieved a million-seller with a recitation song as a tribute to his mother and mothers everywhere called "I.O.U." The song was released a few weeks before Mother's Day and quickly became a Top 10 country hit, his first one in a decade, and a Top 40 pop hit, his first in 14 years. The song was re-released in 1977, 1983 and 1984, but with minor success each time.

Business career

In 1969, he founded the Jimmy Dean Sausage Company with his brother Don. The company did well, in part because of Dean's own extemporized, humor-themed commercials.

Its success led to its acquisition in 1984 by Consolidated Foods, later renamed the Sara Lee Corporation. Dean remained involved in running the company, but the new corporate parent eventually began phasing him out of any management duties, a period that took a toll on his health. In January 2004, Dean said that Sara Lee had dropped him as the spokesman for the sausage brand, saying that he was too old.

Later years and death

A Virginia resident since 1990, Dean was inducted into the Virginia Country Music Hall of Fame in 1997. Former Virginia governor Jim Gilmore appointed Dean to the Virginia Board of Game and Inland Fisheries, which oversees the state's wildlife efforts and boating laws.

In the fall of 2004, he released his blunt, straight-talking autobiography ''30 Years of Sausage, 50 Years of Ham''. Dean lived in semi-retirement with second wife, Donna Meade Dean, a singer, songwriter, and recording artist he married in 1991, who helped him write his book. The couple lived on their property at Chaffin's Bluff overlooking the James River in Henrico County, on the outskirts of Richmond, Virginia. On April 20, 2009, the main house was largely gutted by a fire, although the Deans escaped injury. The Deans rebuilt their home on the same foundation and returned early in 2010.

Dean, who dropped out of high school in 1946 to work to help his mother, announced on May 20, 2008, a donation of $1 million to Wayland Baptist University in Plainview, the largest gift ever from one individual to the institution. Dean said: "I've been so blessed, and it makes me proud to give back, especially to my hometown."

On February 23, 2010, Dean was inducted into the Country Music Hall of Fame. He was to have been inducted in October.

Dean had three children, Garry, Connie, and Robert, with his first wife Mary Sue (née Wittauer) Dean; and two granddaughters, Caroline Taylor (Connie's daughter) and Brianna Dean (Robert's daughter).

Dean died at the age of 81, on June 13, 2010, of natural causes at his home in Varina, Virginia. He is also survived by his second wife Donna and his nephew, country music singer Billy Dean.

He was entombed in a piano-shaped mausoleum overlooking the James River on the grounds of his estate. His epitaph reads "Here Lies One Hell of a Man".

Discography

References

External links

*

Interview with Jimmy Dean

''The Jimmy Dean Show'' at Muppet Wiki

"Why Jimmy Dean started making sausage"

"Jimmy Dean--AN INTERVIEW WITH “THE DEAN OF COUNTRY MUSIC," with Bill Miller

Category:1928 births Category:2010 deaths Category:American country singers Category:American film actors Category:American television personalities Category:American food industry businesspeople Category:People from Hale County, Texas Category:People from Plainview, Texas Category:People from Henrico County, Virginia Category:Grammy Award winners Category:Four Star Records artists Category:Starday Records artists Category:Mercury Records artists Category:Musicians from Texas Category:Apex Records artists Category:RCA Victor artists Category:Columbia Records artists Category:Baptists from the United States Category:Country Music Hall of Fame inductees

de:Jimmy Dean fr:Jimmy Dean ja:ジミー・ディーン pt:Jimmy Dean sv:Jimmy Dean